BHP WORKS Járműipari Fejlesztö Kft.

Services offered by this workshop

Inspections/Checks

• Computer diagnostics
• Basic inspection
• Extended vehicle inspection
• Pre-purchase inspection
• Summer inspection
• Winter inspection
• Pre-journey inspection
• Replacing the fire extinguisher
• Car ozonation

Diagnostics

• Error code deleting on a car
• Deleting interval inspections
• Diagnosis

Brakes

• Brake system repair
• Brake pads replacement (front)
• Brake pads replacement rear
• Brake Pad Change
• Brake disk replacement (front)
• Brake disk replacement (rear)
• Brake disk replacement
• Brake shoe replacement
• Replacement of brake cylinders
• Brake drum replacement
• Brake carrier replacement
• Brake adjuster replacement
• Brake drum repair
• Handbrake cable replacement
• Flexible brake hose replacement
• Metal brake hose replacement
• Brake master cylinder replacement
• Brake fluid replacement
• ABS sensor replacement
• Brake system verification

Oils, filters, liquids, belts

• Engine oil and oil filter change
• V-belt replacement
• Timing belt replacement
• Timing chain replacement
• Transmission fluid and filter replacement in manual transmission
• Coolant replacement
• Air filter replacement
• Cabin filter replacement

Cooling system

• Engine radiator replacement
• Temperature sensor replacement
• Thermostat replacement
• Radiator fan replacement
• Heater replacement
• Replacement of cooling system hoses
• Water pump replacement
• Radiator fan coupling (visco) replacement
• Heater resistor replacement
• Fan thermo-switch/sensor replacement
• Cooling system repair
• Cooling system verification

Air supply system

• Intake manifold replacement
• Intake manifold gasket replacement
• Intake hose replacement
• Intake hose gasket replacement
• Air flowmeter replacement - mass sensor
• Intake system repair

Steering system

• Tie rod replacement
• Tie rod end replacement
• Steering gear replacement
• Wheel steering knuckle replacement
• Steering column joint replacement
• Power steering pump replacement
• Power steering fluid change
• Steering system repair
• Rubber boot replacement, steering knuckle
• Steering system verification

Powertrain

• Axle shaft replacement
• Axle shaft sealer replacement
• Drive shaft replacement
• Ball joint boot replacement
• Complete clutch kit replacement
• Complete clutch kit with dual-mass flywheel replacement
• Clutch plate replacement
• Clutch cover replacement
• Clutch release bearing replacement
• Clutch cable replacement
• Clutch slave cylinder replacement
• Clutch master cylinder replacement
• Drive system repair
• Differential oil change
• Transmission fluid and filter replacement in automatic transmission
• Powertrain verification

Fuel System

• Fuel injectors replacement
• Pump injector units replacement
• Fuel pump replacement
• Injection pump replacement
• Fuel tank replacement
• Fuel hose replacement
• Fuel filter replacement
• Fuel system cleaning
• Fuel system repair
• Fuel system verification

Exhaust System

• Exhaust manifold replacement
• Exhaust manifold gasket replacement
• Complete muffler replacement
• Exhaust centre pipe replacement
• Exhaust muffler replacement
• Vibration damper replacement
• Muffler gasket
• Muffler hanger repair
• Lambda sensor replacement
• Exhaust system repair
• EGR valve replacement
• Exhaust system verification

Engine

• Rocker cover gasket replacement
• Oil sump gasket replacement
• Engine head gasket replacement
• Valve seals replacement
• V-belt tensioner replacement
• Accelerator cable replacement
• Pulley replacement
• Guide roll replacement
• Tensioner roll replacement
• Idle run regulation replacement
• Timing change
• Engine valve replacement
• Piston rings replacement
• Piston pin replacement
• Connecting rod bearing replacement
• Connecting rod bearings replacement
• Piston replacement
• Camshaft replacement
• Crankshaft replacement
• Engine repair
• Hood or boot lid air-spring replacement
• Safety belt replacement
• Flywheel replacement
• Turbocharger replacement
• Engine verification

Suspensions

• Stabilizer replacement
• Stabilizer bar replacement
• Stabilizer rubber sleeve replacement
• Control arm replacement
• Wishbone silent block replacement
• Ball joint replacement
• Shock absorber replacement
• Shock absorber bearing replacement
• Shock absorber buffer replacement
• Shock absorber rubber boot replacement
• Suspension spring replacement
• MacPherson strut replacement
• Wheel hub replacement
• Wheel bearing replacement
• Suspension repair

MOT Center

• MOT test

Tyres and rims

• Tyre change up to 13" - steel rim
• Tyre change up to 13" - alloy rim
• Tyre change 14"-16" - steel rim
• Tyre change 14"-16" - alloy rim
• Tyre change 17"-19" - alloy rim
• Tyre change
• Car tyre repair
• Tyre valve replacement
• Wheel balancing
• Off Road tyre and rim fitting/disassembly
• 13”-17” tyre change with balance
• Tyre change 17"-19" - steel rim

Automotive electrical system

• Battery replacement
• Battery charging test
• Headlight bulb replacement
• Light bulb replacement (Rear)
• Xenon bulbs replacement
• Lights regulation
• Parking sensor fitting
• Dashboard gauges replacement
• Spark/glow plugs replacement
• Ignition leads replacement
• Ignition coil replacement
• Ignition module replacement
• Distributor cap replacement
• Distributor rotor replacement
• Starter replacement
• Alternator replacement
• Fuse replacement
• Wiper blade motor replacement
• Windscreen washer pump replacement
• Indicator breaker replacement
• Battery load test
• Window regulator repair
• Ignition switch replacement
• Light level regulation motor replacement
• Wiper tie rod replacement
• Central locking servomotor replacement
• License plate light-bulb replacement
• Glow plugs replacement

Car electronics

• Idle running sensor replacement
• Oil pressure sensor replacement
• Fuel pressure sensor replacement
• Exhaust fumes pressure sensor replacement
• Intake manifold pressure sensor replacement
• Brake system pressure sensor replacement
• DeNOx module pressure sensor replacement
• Ignition Hall sensor replacement
• Fuel injection system sensor and transmitter replacement
• Pulse sensor / pulser replacement
• A/C sensor replacement
• Rev counter sensor replacement
• Oil sensor replacement
• Door sensor replacement
• Accelerator pedal position sensor replacement
• Clutch pedal position sensor replacement
• Throttle position sensor replacement
• Camshaft position sensor replacement
• Crankshaft sensor replacement
• Engine oil level sensor replacement
• Replacing fuel level sensor
• Coolant level sensor replacement
• Brake fluid level sensor replacement
• Windscreen washer fluid level sensor replacement
• Brake position sensor replacement
• Steering wheel sensor replacement
• Transmission sensor replacement
• Knock sensor replacement
• Speed sensor replacement
• Stop lights sensor replacement
• Oil temperature sensor replacement
• Fuel temperature sensor replacement
• Coolant temperature sensor replacement
• Intake air temperature sensor replacement
• Exhaust fumes temperature sensor replacement
• External temperature sensor replacement
• NOx sensor replacement
• Cooling system sensor replacement
• Brake pad wear sensor replacement
• Sensor/relay replacement
• Electronics verification

Windows and mirrors

• Front / rear window heating repair
• Windscreen replacement
• Rear window replacement
• Side window pane replacement - opening
• Side window pane replacement - not-opening
• Sun roof repair, replacement
• Mirror glass replacement
• Glass cracks/chips repair
• Replacement of body window pane

Body parts replacement

• Bumper replacement
• Fender replacement
• Engine bonnet replacement
• Boot lid replacement
• Front door replacement
• Rear door replacement
• Roof replacement
• Front quarter replacement
• Rear quarter replacement
• Car side sill replacement
• Header panel replacement
• Rear panel replacement
• Headlamp replacement
• Indicator replacement
• Tail light replacement
• Mirror replacement
• Fender liner replacement
• Engine bottom cover replacement

Body parts repairs

• Bumper repair
• Fender repair
• Engine bonnet repair
• Boot lid repair
• Front door repair
• Rear door repair
• Roof repair
• Front quarter repair
• Rear quarter repair
• Car side sill repair
• Header panel repair
• Rear panel repair

Body parts painting

• Whole car body painting
• Front bumper painting
• Rear bumper painting
• Front fender painting
• Rear fender painting
• Engine bonnet painting
• Boot lid painting
• Front door painting
• Rear door painting
• Roof painting
• Front quarter painting
• Rear quarter painting
• Car side sill painting
• Header panel painting
• Rear panel painting
• Mirror painting

Vehicle tuning and sports modifications

• Sports air filter fitting
• Sports oil filter fitting
• Assembling Track Day tires
• Fitting of High Performance tires
• Competitive tyre assembly
• Sports brakes servicing
• Fitting sports brake disks
• Fitting sports brake pads
• Fitting sports brake fluid
• Fitting braided brake cables
• Sports suspension servicing
• Fitting sports shock absorbers
• Lowering springs fitting
• Assembly of springs for increased load
• Support fitting
• Fitting sports stabilizers
• Sport suspension sleeve fitting
• Sport suspension kit fitting
• Fitting sports gauges
• Xenon lights fitting
• Wrought piston fitting
• Fitting sports connecting rod bearings
• Fitting sports valves
• Sports camshaft fitting
• Fitting sports spark plugs
• Fitting sports ignition leads
• Sports cooling system fitting
• Fuel pressure regulation valve fitting
• Fitting sports fuel pump
• Sports exhaust system fitting
• Fitting sports drive transmission
• Sports engine oil change
• Sports transmission fluid change
• Changing sports coolant

Off-road service

• Off Road shock absorbers fitting
• Off Road turn damper fitting
• Off Road springs fitting
• Off Road leaf springs fitting
• Off Road U-Bolts fitting
• Off-Road suspension bush replacement
• Off Road winch fitting
• Off Road snorkel fitting
• Off Road additional lights fitting
• Off Road fender modification
• Off-road axle lock fitting
• Off-road hub clutch fitting

Accessories

• Roof rack installation
• Fitting roof railings
• Roof rack (box) installation
• Wiper blade replacement

Breakdown / Urgent Help

• Road assistance / breakdown service

Batteries for electric / hybrid vehicles

• Electric vehicle high voltage battery check
• Hybrid vehicle battery check

Advanced driver-assistance systems (ADAS)

• Adaptive cruise control system (ACC) calibration